低渗透性煤体电脉冲水压致裂效果及规律研究

油气藏评价与开发 ›› 2018, Vol. 8 ›› Issue (5): 64-69.

低渗透性煤体电脉冲水压致裂效果及规律研究

鲍先凯^1,²,段东明¹,曹嘉星¹,武晋文³,赵金昌²

^1. 内蒙古科技大学土木工程学院,内蒙古包头 014010
^2. 太原理工大学矿业工程学院,山西太原 030024
^3. 中北大学理学院,山西太原 030051

收稿日期:2018-03-16 发布日期:2018-12-05 出版日期:2018-10-26
作者简介:先凯（1974—）,男,在读博士,副教授,煤层气开采及利用方面的研究。
基金资助:
内蒙古自然科学基金“基于高压电脉冲水压致裂的低渗透性煤层气解吸增透效果试验研究”(2016MS0511);国家自然基金青年科学基金项目“岩石高温三轴压裂机理研究”(51504220);山西省自然科学基金“静水压力作用下脉冲放电水激波不同速率动载组合致裂低渗透煤层机理研究”(201701D121132)

Study on effect and law of electric pulse hydraulic fracturing of low permeability coal

Bao Xiankai^1,²,Duan Dongming¹,Cao Jiaxing¹,Wu Jinwen³,Zhao Jinchang²

^1. School of Civil Engineering, Inner Mongolia University of Science and Technology, Baotou, Inner Mongolia 014010, China
^2. School of Mining Technology, Taiyuan University of Technology, Taiyuan, Shanxi 030024, China
^3. School of Science, North University of China, Taiyuan, Shanxi 030051, China

Received:2018-03-16 Online:2018-12-05 Published:2018-10-26

摘要/Abstract

摘要：

为了揭示电脉冲水压致裂技术对低渗透性煤体裂纹的作用效果和规律,基于液电效应原理,进行了高压电脉冲水压压裂理论分析和室内实验。共制作了3个试件,在3 MPa静水压力不变的情况下,分别施加不同的电压（9 kV、11 kV、13 kV）,利用超声波无损检测技术分别对实验前后的煤样进行扫描,分析煤样内部裂纹的分布和扩展情况,建立数值模型分析实验条件下裂纹的扩展规律和周边应力。结果表明：超声波首波声时的变化能够很好的反映出实验前后煤体试件裂纹的变化情况;单纯的3 MPa静水压力产生裂纹效果甚微;随着水中放电电压的增加,试件内部新生裂纹逐渐增多,裂纹密度增大,裂隙区域逐渐从中央钻孔向试件边缘扩展,煤体产生裂纹效果明显;在加载过程中,应力最大值逐渐增大,并随着裂纹的扩展而发生转移。

关键词: 高压电脉冲, 超声波无损检测, 液电效应, 裂纹

Abstract:

In order to reveal the effect and rule of hydraulic fracturing by high voltage electric pulse on coal crack, the analysis and the experiment about high voltage electrical hydraulic fracturing was carried out based on the principle of electro-hydraulic effect. Then three specimens were made. In the case of constant hydrostatic pressure at 3 MPa, different voltages（9 kV, 11 kV and 13 kV） were applied. The coal samples before and after the experiment were respectively scanned by ultrasonic nondestructive testing techniques to analyze the distribution and expansion of the coal internal cracks, and establish the numerical model to analyze the crack propagation rule and the surrounding stress distribution under experimental conditions. The results showed that the changes of the head ultrasonic wave's time could reflect the change of the crack in the coal sample before and after the experiment. The effect of the pure hydrostatic pressure at 3 MPa on the crack was very slight. While with the increase of the discharge voltage in the water, the new cracks inside the specimen and the density of cracks increased, and the fissure area extended from the central drilling to the edge of the test piece, coal crack effect was obvious. During the loading process, the maximum stress increased gradually and changed with the crack propagation.

Key words: high voltage electric pulse, ultrasonic nondestructive testing, electro-hydraulic effect, crack

中图分类号:

TE122

鲍先凯,段东明,曹嘉星等. 低渗透性煤体电脉冲水压致裂效果及规律研究[J]. 油气藏评价与开发, 2018, 8(5): 64-69.

Xiankai Bao,Dongming Duan,Jiaxing Cao, et al. Study on effect and law of electric pulse hydraulic fracturing of low permeability coal[J]. Reservoir Evaluation and Development, 2018, 8(5): 64-69.

图/表 9

图1

表1

图2

图3

图4

表2

图5

图6

图7

参考文献 16

[1]	郭继圣, 张宝优 . 我国煤层气(煤矿瓦斯)开发利用现状及展望[J]. 煤炭工程, 2017,49(3):83-86.
[2]	鲜保安, 高德利, 李安启 , 等. 煤层气定向羽状水平井开采机理与应用分析[J]. 天然气工业, 2005,25(1):114-116. doi: 10.3321/j.issn:1000-0976.2005.01.033
[3]	杨恒林, 汪伟英, 田中兰 . 煤层气储层损害机理及应对措施[J]. 煤炭学报, 2014,39(S1):158-163.
[4]	Clarkson C R, Rahmanian M, Kantzas A, et al. Relative permeability of CBM reservoirs: Controls on curve shape[C]// paper SPE-137404-MS presented at the Canadian Unconventional Resources and International Petroleum Conference, 19-21 October 2010, Calgary, Alberta,Canada.
[5]	孙可明 . 低渗透煤层气开采与注气增产流固耦合理论及其应用[D]. 辽宁:辽宁工程技术大学, 2004.
[6]	Yang T, Nie B, Yang D , et al. Experimental research on displacing coal bed methane with supercritical CO₂[J]. Safety Science, 2012,50(4):899-902. doi: 10.1016/j.ssci.2011.08.011
[7]	翟成, 李贤忠, 李全贵 . 煤层脉动水力压裂卸压增透技术研究与应用[J]. 煤炭学报, 2011,36(12):1996-2001.
[8]	林柏泉, 孟杰, 宁俊 , 等. 含瓦斯煤体水力压裂动态变化特征研究[J]. 采矿与安全工程学报, 2012,29(1):106-110. doi: 10.3969/j.issn.1673-3363.2012.01.019
[9]	周声才, 李栋, 张凤舞 , 等. 煤层瓦斯抽采爆破卸压的钻孔布置优化分析及应用[J]. 岩石力学与工程学报, 2013,32(4):807-813. doi: 10.3969/j.issn.1000-6915.2013.04.020
[10]	姜文理, 刘钟阳, 许东卫 . 液电效应催化臭氧氧化处理染料废水的研究[J]. 高电压技术, 2007,33(2):145-149.
[11]	张雷, 邓琦林, 周锦进 . 液电效应除垢机理分析与试验研究[J]. 大连理工大学学报, 1998,38(2):87-91.
[12]	李树杰, 张毅 . 液电效应处理污水的实验研究[J]. 中国微生态学杂志, 1996,8(1):63-64+52.
[13]	尤特金 . 液电效应[M]. 北京: 科学出版社, 1962: 9-10.
[14]	张平, 李宁, 贺若兰 , 等. 动载下两条断续预制裂隙贯通机制研究[J]. 岩石力学与工程学报, 2006,25(6):1210-1217. doi: 10.3321/j.issn:1000-6915.2006.06.019
[15]	张治泰, 邱平 . 超声波在混凝土质量检测中的应用[M]. 北京: 化学工业出版社, 2006.
[16]	Hu K X, Huang Y . Estimation of the elastic properties of fractured rock masses[J]. International Journal of Rock Mechanics & Mining Science & Geomechanics Abstracts, 1993,30(4):381-394. doi: 10.1016/0148-9062(93)91721-T

试件编号	放电电压/kV	静水压/MPa	采样频率/Hz
S-1	9	3	500
S-2	11	3	500
S-2	13	3	500

项目	密度/ （kg·m^-3）	泊松比	弹性模量/MPa	内摩擦角/（°）	压拉比（C/T）
平均值	1 500	0.2	3 400	32	20
均质度系数	100	100	3