基于响应面法的油田深部地层变形的数值试验研究

Abstract

Abstract:

During the development of the oilfield, the water flooding disturbs the primary reservoir pressure, leads to the deformation of the deep formation in the oilfield and affects the extraction ratio of oil. In order to obtain the main effect parameters of the deformation, an experiment with 3 levels for 5 parameters was conducted by Hyper-Latin square experiment based on fluid-solid coupling theory. Then, the relationships among the deformation response and the different parameters were obtained after the regression and analysis by RSM method for 33 designed experiments. The results show that the injection pressure has significant influence on the effective stress and deformation. And the properties of the reservoirs affect more on the initial stage for the effective stress, however, the later period for the normal strain. The elastic modulus of the rock mechanics properties has little effect on the effective stress, and is a significant parameter for the normal strain and subsidence.

Key words: water flooding, stratum deformation, hyper-latin square experiment, response surface method, effect factor

CLC Number:

TE341

Jianjun Liu,Yongxiang Zheng,Bohu Zhang, et al. Numerical study on deformation of deep formation in oilfield based on response surface method[J]. Reservoir Evaluation and Development, 2018, 8(1): 16-23.

Figures/Tables 12

Fig. 1

Table 1

Table 2

Table 3

Table 4

Table 5

Fig. 2

Fig. 3

Fig. 4

Fig. 5

Fig. 6

Fig. 7

References 24

[1]	许华明, 曲国胜, 李行船 , 等. 注水诱发地震的成因及影响因素探讨[J]. 西北地震学报, 2008,30(3):221-226. doi: 10.3969/j.issn.1000-0844.2008.03.004
[2]	仵彦卿 . 岩土水力学[M]. 北京: 科学出版社, 2009.
[3]	刘业科 . 水岩作用下深部岩体的损伤演化与流变特性研究[D]. 中南大学, 2012.
[4]	Hu S, Li Y, Wang Z , et al. A new approach of proration-injection allocation for water-flooding mature oilfields[J]. Petroleum, 2015,1(1):27-30. doi: 10.1016/j.petlm.2015.03.009
[5]	Zhang Q, Ju Y, Gong W , et al. Numerical simulations of seepage flow in rough single rock fractures[J]. Petroleum, 2015,1(3):200-205. doi: 10.1016/j.petlm.2015.09.003
[6]	Chen L, Liu J . Numerical analysis on the crack propagation and failure characteristics of rocks with double fissures under the uniaxial compression[J]. Petroleum, 2015,1(4):373-381. doi: 10.1016/j.petlm.2015.10.009
[7]	Shangguan Y, Zhang Y, Xiong W . The effect of physical property change on the water flooding development in Changqing oilfield Jurassic low permeability reservoir[J]. Petroleum, 2015,1(4):300-306. doi: 10.1016/j.petlm.2015.10.010
[8]	Orlic B, Heege J T, Wassing B . Assessing the integrity of fault- and top seals at CO₂ storage sites[J]. Energy Procedia, 2011,4(1):4 798-4 805. doi: 10.1016/j.egypro.2011.02.445
[9]	Li Q, Xing H, Liu J , et al. A review on hydraulic fracturing of unconventional reservoir[J]. Petroleum, 2015,1(1):8-15. doi: 10.1016/j.petlm.2015.03.008
[10]	王金生 . 场地变形的多孔介质液固互动分析[D]. 河北联合大学, 2012.
[11]	Yin S, Dusseault M B, Rothenburg L . Coupled THMC modeling of CO₂ injection by finite element methods[J]. Journal of Petroleum Science and Engineering, 2011,80(1):53-60. doi: 10.1016/j.petrol.2011.10.008
[12]	Altmann J B, Müller B I R, Müller T M , et al. Pore pressure stress coupling in 3D and consequences for reservoir stress states and fault reactivation[J]. Geothermics, 2014,52(4):195-205. doi: 10.1016/j.geothermics.2014.01.004
[13]	Youjun J, Jie W, Liuke H . Analysis on inflowing of the injecting Water in faulted formation[J]. Advances in Mechanical Engineering, 2015,7(6):1-10.
[14]	姜涛 . 基于热流固耦合注水地层及套管损坏分析[D]. 东北石油大学, 2011.
[15]	Rutqvist J, Birkholzer J T, Tsang C . Coupled reservoir-geomechanical analysis of the potential for tensile and shear failure associated with CO₂ injection in multilayered reservoir-caprock systems[J]. International Journal of Rock Mechanics and Mining Sciences, 2008,45(2):132-143. doi: 10.1016/j.ijrmms.2007.04.006
[16]	Rutqvist J, Vasco D W, Myer L . Coupled reservoir-geomechanical analysis of CO₂ injection at In Salah, Algeria[J]. Energy Procedia, 2009,1(1):1 847-1 854. doi: 10.1016/j.egypro.2009.01.241
[17]	Kaldi J, Daniel R, Tenthorey E , et al. Containment of CO₂ in CCS: Role of caprocks and faults[J]. Energy Procedia, 2013,37:5 403-5 410. doi: 10.1016/j.egypro.2013.06.458
[18]	Shen Y, Liu H, Wang H , et al. Wellbore instability induced by alternating water injection and well washing with an elasto-plastic erosion model[J]. Journal of Natural Gas Science and Engineering, 2015,27(3):1 863-1 870. doi: 10.1016/j.jngse.2015.11.016
[19]	Shen Y, Liu H, Wang H , et al. Initiation and propagation of wormhole in unconsolidated rock matrix induced by long-term water injection[J]. Journal of Petroleum Science and Engineering, 2015,127:93-100. doi: 10.1016/j.petrol.2015.01.032
[20]	Kim J, Moridis G J . Numerical analysis of fracture propagation during hydraulic fracturing operations in shale gas systems[J]. International Journal of Rock Mechanics and Mining Sciences, 2015,76:127-137. doi: 10.1016/j.ijrmms.2015.02.013
[21]	Ghafari E, Costa H, Júlio E . RSM-based model to predict the performance of self-compacting UHPC reinforced with hybrid steel micro-fibers[J]. Construction and Building Materials, 2014,66(5):375-383. doi: 10.1016/j.conbuildmat.2014.05.064
[22]	Khayat K H, Ghezal A, Hadriche M S . Utility of statistical models in proportioning self-consolidating concrete[J]. Materials and Structures, 2000,33(5):338-344. doi: 10.1007/BF02479705
[23]	Anupam K, Dutta S, Bhattacharjee C , et al. Optimisation of adsorption efficiency for reactive red 198 removal from wastewater over TiO₂ using response surface methodology[J]. The Canadian Journal of Chemical Engineering, 2011,89(5):1 274-1 280. doi: 10.1002/cjce.v89.5
[24]	Li J, Liu Q, Ji Q Q , et al. Degradation of p-nitrophenol(PNP) in aqueous solution by Fe₀-PM-PS system through response surface methodology(RSM)[J]. Applied Catalysis B: Environmental, 2017,200:633-646. doi: 10.1016/j.apcatb.2016.07.026

水平	变量
水平	渗透率 k/10^-3μm²	孔隙度 φ,f	注水压力 P_w/MPa	初始地层压力 P₀/MPa	岩石弹性模量E/GPa
0（0.8）	16	0.24	12	8	6.78
1（1.0）	20	0.30	15	10	8.47
2（1.2）	24	0.36	18	12	10.16

编号	实验方案	编号	实验方案	编号	实验方案
1	0000010100	12	0101020000	23	0002000201
2	0102000001	13	0202000000	24	0202010101
3	0100020100	14	0002020201	25	0201020001
4	0001020101	15	0202010201	26	0001020000
5	0200000100	16	0000000002	27	0201000202
6	0202010001	17	0101020202	28	0100010102
7	0200020202	18	0201000200	29	0101010200
8	0000000100	19	0200010202	30	0202020102
9	0100010001	20	0001000201	31	0101000001
10	0002020102	21	0100010002	32	0101020100
11	0000010102	22	0102000002	33	0002010200

因素	回归系数	标准差	t值	P值
常数	29 617.4	68.703 29	431.091	<0.000 01
E（6.78×10⁶,1.016×10⁷）	23.373 13	21.631 16	1.080 53	0.301 14
P₀（8×10³,1.2×10⁴）	1 177.089	25.117 87	46.862 6	<0.000 01
k（16,24）	-225.960 4	21.804 82	-10.362 9	<0.000 01
φ（0.24,0.36）	160.587 8	26.526 95	6.053 76	0.000 06
P_w（1.2×10⁴,1.8×10⁴）	-1 522.954	20.764 36	-73.344 6	<0.000 01
EE	9.073 169	51.925 04	0.174 736	0.864 20
EP₀	42.280 2	32.100 86	1.317 1	0.212 40
Ek	-57.123 08	31.138 33	-1.834 49	0.091 48
Eφ	22.463 65	29.966 81	0.749 618	0.467 93
EP_w	38.165 44	29.230 59	1.305 67	0.216 14
P₀P₀	57.465 04	59.087 62	0.972 539	0.349 98
P₀k	19.076 9	35.510 81	0.537 214	0.600 94
P₀φ	-3.693 091	37.533 44	-0.098 394 7	0.923 24
P₀P_w	96.445 44	33.461 93	2.882 24	0.013 77
kk	64.991 98	55.713 54	1.166 54	0.266 06
kφ	15.744 67	35.033	0.449 424	0.661 14
kP_w	-275.649 4	26.956	-10.225 9	<0.000 01
φφ	12.922 98	45.157 43	0.286 176	0.779 62
φP_w	89.019 64	32.496 48	2.739 36	0.017 95
P_wP_w	-643.297 6	40.712 85	-15.800 8	<0.000 01

变量因子	有效应力	水平应变	竖向沉降
E（6.78×10⁶,1.016×10⁷）	不显著	-8.541	5.441 8
EP_w	不显著	-7.109 1	11.772
EP₀	不显著	不显著	-6.556 1
Ek	-1.471 5	不显著	-2.289 8
P_w（1.2×10⁴,1.8×10⁴）	-82.816	30.682	-62.691
P_wP_w	-18.371	6.725 4	-15.207
P₀（8×10³,1.2×10⁴）	61.14	不显著	48.602
P₀P_w	5.375 5	不显著	不显著
k（16,24）	-13.349	2.582 8	-9.349 3
kP_w	-12.162	不显著	-7.374 4
kk	不显著	不显著	4.432 4
φ（0.24,0.36）	8.134 9	不显著	5.800 2
φP_w	5.092 9	不显著	不显著

变量因子	有效应力	水平应变	竖向沉降
E（6.78×10⁶,1.016×10⁷）	不显著	-19.485	33.78
EE	不显著	不显著	-3.526 7
Ek	5.765 2	不显著	2.067
EP₀	-5.489 7	不显著	-22.268
EP_w	不显著	-5.122 3	31.057
Eφ	不显著	不显著	-2.885 6
k（16,24）	-30.315	-6.735 7	-16.335
kP_w	8.773 6	-6.596 6	3.700 9
P₀（8×10³,1.2×10⁴）	270.43	不显著	112.91
P₀k	-1.995	不显著	-2.845
P₀P₀	-3.009 2	不显著	不显著
P₀P_w	-2.557 5	不显著	不显著
P₀φ	2.331 1	不显著	3.833 8
P_w（1.2×10⁴,1.8×10⁴）	-447.49	35.195	-198.42
P_wP_w	12.154	-10.709	4.165 5
φ （0.24,0.36）	10.248	6.092 9	4.510 7
φ P_w	-6.481 6	4.902 2	-1.892 7

Numerical study on deformation of deep formation in oilfield based on response surface method

RichHTML

PDF (PC)

Like

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 12

References 24

Related Articles 6

Metrics

Comments

Recommended 0

[1]	CHEN Ke,ZHANG Xudong,HE Wei,YIN Chao,TANG Lei,ZHANG Hu,YE Zhongbin. Influence of micro displacement effect of permeability on water flooding and the direction of tapping potential of fluvial reservoir [J]. Petroleum Reservoir Evaluation and Development, 2021, 11(5): 694-702.
[2]	He Yunfeng,Yang Xiaoteng. Relation between water invasion coefficient and stable production period in gas reservoirs with active edge water [J]. Reservoir Evaluation and Development, 2021, 11(1): 124-128.
[3]	XIONG Yu,ZHONG Hao,ZHOU Wensheng,LIU Cheng,GOU Li. Water driving physical simulation test of remaining oil based on 3D large-scale heterogeneous reservoir model [J]. Reservoir Evaluation and Development, 2019, 9(6): 16-23.
[4]	SHI Leiting,ZHU Shijie,ZOU Jian,XUE Xinsheng,ZHAO Wensen,YE Zhongbin. Study on effective mobility control time ramge and influencing factors of polymer flooding [J]. Reservoir Evaluation and Development, 2019, 9(4): 31-35.
[5]	FANG Yujia,YANG Erlong,YIN Daiyin. Study on utilization ratio of remaining oil in fractured low permeability reservoirs at different water cut stages [J]. Reservoir Evaluation and Development, 2019, 9(4): 12-18.
[6]	Li Ke,Hu Shuyong,Zhang Jinqing,Zhu Guojin,Zhou Wensheng,Geng Yanhong. A new type water flooding characteristic curve and its application [J]. Reservoir Evaluation and Development, 2019, 9(2): 13-16.