纳米颗粒强化泡沫压裂液的构建及其稳泡机理研究

doi:10.13809/j.cnki.cn32-1825/te.2023.02.016

Abstract

Abstract:

The synergistic effect of SiO₂ nanoparticles （SNP） and surfactants can provide a new idea for the preparation of foam fracturing fluid suiTable for harsh formation conditions. In order to prove it, the synergistic foam stabilization ability of SNP and five types of surfactants is evaluated, and the optimal foams system is selected based on the foams comprehensive value. The proppant carrying ability, rheology, and stability of the selected foam fracturing fluid system are evaluated, and the performance improvement of the fracturing fluid by SNP is analyzed. At the same time, the optical microscope observation and SEM experiment are used to reveal the foam stabilization mechanism of SNP. The system screening experiments show that the synergistic effect of TTAB and SNP is the most obvious. The comprehensive foam value reaches 15 288 mm·s, and the half-time of water drainage increases by 145 %. The performance evaluation experiments show that SNP can improve the elastic modulus of the interfacial liquid film, improve the proppant supporting capacity of the liquid film, reduce the settling velocity of proppant which help foam fracturing fluid bring proppants into deeper fractures. SNP can also improve the surface roughness of liquid film and thus enhance the shear resistance of foam fracturing fluid. Adding proppants to the system can weaken the stability of foam. The weakening effect of ceramsite is stronger than that of quartz sand, and the weakening effect of high mesh size is stronger than that of low mesh size. The stabilization mechanism study is revealed by the SNP aggregation at Plateau is observed in the foam microstructure which can block the drainage channels. Moreover, SNP could prevent the coarsening and drainage of foam. By the macroscopic observation, SNP-stabilized bubbles are more stable in term of more bubble number, smaller bubble size and more uniform bubble size distribution.

Key words: foam fracturing fluid, silica nanoparticle, system screening, foam properties evaluation, stabilization mechanism of foams

CLC Number:

TE357

Zhaozhong YANG,Nanxin ZHENG,Jingyi ZHU, et al. Preparation of nanoparticle-stabilized foam fracturing fluid and its foam stabilization mechanism[J]. Reservoir Evaluation and Development, 2023, 13(2): 260-268.

Figures/Tables 16

Table 1

Fig. 1

Fig. 2

Fig. 3

Fig. 4

Fig. 5

Fig. 6

Fig. 7

Fig. 8

Fig. 9

Fig. 10

Fig. 11

Fig. 12

Fig. 13

Fig. 14

Fig. 15

References 24

[1]	罗成. CO₂准干法压裂技术研究及应用[J]. 石油与天然气化工, 2021, 50(2): 83-87.
	LUO Cheng. Research and application of quasi-dry CO₂ fracturing technology[J]. Chemical Engineering of Oil & Gas, 2021, 50(2): 83-87.
[2]	蒋廷学, 左罗, 黄静. 少水压裂技术及展望[J]. 石油钻探技术, 2020, 48(5): 1-8.
	JIANG Tingxue, ZUO Luo, HUANG Jing. Development trends and prospects of less-water hydraulic fracturing technology[J]. Petroleum Drilling Techniques, 2020, 48(5): 1-8.
[3]	徐凤银, 王勃, 赵欣, 等. “双碳”目标下推进中国煤层气业务高质量发展的思考与建议[J]. 中国石油勘探, 2021, 26(3): 9-18. doi: 10.3969/j.issn.1672-7703.2021.03.002
	XU Fengyin, WANG Bo, ZHAO Xin, et al. Thoughts and suggestions on promoting high quality development of China's CBM business under the goal of “double carbon”[J]. China Petroleum Exploration, 2021, 26(3): 9-18. doi: 10.3969/j.issn.1672-7703.2021.03.002
[4]	杜燕, 刘超, 高潮, 等. 鄂尔多斯盆地延长探区陆相页岩气勘探开发进展挑战与展望[J]. 中国石油勘探, 2020, 25(2): 33-42. doi: 10.3969/j.issn.1672-7703.2020.02.004
	DU Yan, LIU Chao, GAO Chao, et al. Progress, challenges and prospects of the continental shale gas exploration and development in the Yanchang exploration area of the Ordos Basin[J]. China Petroleum Exploration, 2020, 25(2): 33-42. doi: 10.3969/j.issn.1672-7703.2020.02.004
[5]	REIDENBACH V G, HARRIS P C, LEE Y N, et al. Rheological study of foam fracturing fluids using nitrogen and carbon dioxide[J]. SPE Production Engineering, 1986, 1(1): 31-41.
[6]	杨兆中, 朱静怡, 李小刚, 等. 纳米颗粒稳定泡沫在油气开采中的研究进展[J]. 化工进展, 2017, 36(5): 1675-1681.
	YANG Zhaozhong, ZHU Jingyi, LI Xiaogang, et al. Research progresses on nanoparticle-stabilized foams in oil and gas production[J]. Chemical Industry and Engineering Progress, 2017, 36(5): 1675-1681.
[7]	刘子铭, 葛际江, 李嘉苏, 等. 长短碳链甜菜碱型起泡剂的协同增效作用研究[J]. 石油与天然气化工, 2022, 51(5): 92-98.
	LIU Ziming, GE Jijiang, LI Jiasu, et al. Synergistic effect of long and short carbon chain betaine type foaming agent[J]. Chemical Engineering of Oil & Gas, 2022, 51(5): 92-98.
[8]	NGUYEN P, FADAEI H, SINTON D. Pore-scale assessment of nanoparticle-stabilized CO₂ foam for enhanced oil recovery[J]. Energy & Fuels, 2014, 28(10): 6221-6227. doi: 10.1021/ef5011995
[9]	PENG B L, TANG J T, LUO J H, et al. Applications of nanotechnology in oil and gas industry: Progress and perspective[J]. The Canadian journal of chemical engineering, 2018, 96(1): 91-100. doi: 10.1002/cjce.v96.1
[10]	张小芹, 陈岳飞, 周雄, 等. 碳纳米颗粒掺杂过渡金属磷化物的制备及其析氢性能研究[J]. 石油与天然气化工, 2022, 51(5): 51-59.
	ZHANG Xiaoqin, CHEN Yuefei, ZHOU Xiong, et al. Preparation and hydrogen evolution performance of carbon nanoparticles-doped transition metal phosphides[J]. Chemical Engineering of Oil & Gas, 2022, 51(5): 51-59.
[11]	MAGHZI A, MOHEBBI A, KHARRAT R, et al. An experimental investigation of silica nanoparticles effect on the rheological behavior of polyacrylamide solution to enhance heavy oil recovery[J]. Petroleum Science and Technology, 2013, 31(5): 500-508. doi: 10.1080/10916466.2010.518191
[12]	ZHU J Y, YANG Z Z, LI X G, et al. Experimental study on the microscopic characteristics of foams stabilized by viscoelastic surfactant and nanoparticles[J]. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2019, 572: 88-96. doi: 10.1016/j.colsurfa.2019.03.087
[13]	PAL N, VERMA A, OJHA K, et al. Nanoparticle-modified gemini-surfactant foams as efficient displacing fluids for enhanced oil recovery[J]. Journal of Molecular Liquids, 2020, 310: 113193. doi: 10.1016/j.molliq.2020.113193
[14]	ALYOUSEF Z A, ALMOBARKY M A, SCHECHTER D S. The effect of nanoparticle aggregation on surfactant foam stability[J]. Journal of Colloid and Interface science, 2018, 511: 365-373. doi: S0021-9797(17)31082-2 pmid: 29031155
[15]	杨滢. 高温高盐底水油藏氮气泡沫体系控水及机理研究[D]. 西安: 西安石油大学, 2018.
	YANG Ying. Research water control and mechanism of nitrogen foam system in high temperature and high salinity bottom water reservoir[D]. Xi’an: Xi’an Shiyou University, 2018.
[16]	CHU K C, HU S W, TSAO H K, et al. Strong competition between adsorption and aggregation of surfactant in nanoscale systems[J]. Journal of Colloid and Interface science, 2019, 553: 674-681. doi: 10.1016/j.jcis.2019.06.075
[17]	LIU P S, NIU L Y, TAO X H, et al. Preparation of superhydrophobic-oleophilic quartz sand filter and its application in oil-water separation[J]. Applied Surface Science, 2018, 447: 656-663. doi: 10.1016/j.apsusc.2018.04.030
[18]	吴雪鹏. CO₂响应清洁压裂液体系的构筑及循环利用机理研究[D]. 青岛: 中国石油大学(华东), 2018.
	WU Xuepeng. Study on the construction and recycling mechanism of CO₂ response clean fracturing fluid system[D]. Qingdao: China University of Petroleum(East China), 2018.
[19]	彭欢, 桑宇, 杨建, 等. 泡沫压裂液携砂性能评价方法研究进展及展望[J]. 钻采工艺, 2016, 39(3): 87-90.
	PENG Huan, SANG Yu, YANG Jian, et al. research progress and prospect of sand carrying performance evaluation methods of foam fracturing fluid[J]. Drilling & Production Technology, 2016, 39(3): 87-90.
[20]	ZHU J Y, YANG Z Z, LI X G, et al. Settling behavior of the proppants in viscoelastic foams on the bubble scale[J]. Journal of Petroleum Science and Engineering, 2019, 181: 106216. doi: 10.1016/j.petrol.2019.106216
[21]	FEI Y, JOHNSON JR R L, GONZALEZ M, et al. Experimental and numerical investigation into nano-stabilized foams in low permeability reservoir hydraulic fracturing applications[J]. Fuel, 2018, 213: 133-143. doi: 10.1016/j.fuel.2017.10.095
[22]	BINKS B P, KIRKLAND M, RODRIGUES J A. Origin of stabilization of aqueous foams in nanoparticle-surfactant mixtures[J]. Soft Matter, 2008, 4(12): 2373-2382. doi: 10.1039/b811291f
[23]	李兆敏, 王鹏, 李松岩, 等. 纳米颗粒提高二氧化碳泡沫稳定性的研究进展[J]. 西南石油大学学报(自然科学版), 2014, 36(4): 155-161.
	LI Zhaomin, WANG Peng, LI Songyan, et al. Advances of researches on improving the stability of CO₂ foams by nanoparticles[J]. Journal of Southwest Petroleum University(Science & Technology Edition), 2014, 36(4): 155-161.
[24]	BINKS B P, LUMSDON S O. Influence of particle wettability on the type and stability of surfactant-free emulsions[J]. Langmuir, 2000, 16(23): 8622-8631. doi: 10.1021/la000189s

类型	名称	代号	品牌
阴离子	十二烷基肌氨酸钠	SLS	阿拉丁
阴离子	琥珀酸二辛酯磺酸钠	HPS	Sigma
非离子	脂肪醇聚氧乙烯醚	AEO	阿拉丁
阳离子	十八烷基三甲基溴化铵	ETAB	阿拉丁
阳离子	十四烷基三甲基溴化铵	TTAB	阿拉丁

Preparation of nanoparticle-stabilized foam fracturing fluid and its foam stabilization mechanism

RichHTML

PDF (PC)

Like

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 16

References 24

Related Articles 15

Metrics

Comments

Recommended 0

[1]	ZHANG Yi, NING Chongru, CHEN Yazhou, JI Yulong, ZHAO Liyang, WANG Aifang, HUANG Jingjing, YU Kaiyi. Huff-n-puff technology and parameter optimization of large displacement water injection in tight oil reservoir [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(5): 727-733.
[2]	LIAO Kai, ZHANG Shicheng, XIE Bobo. Simulation of reasonable shut-in time for shale oil after volume fracturing [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(5): 749-755.
[3]	LIU Xugang, LI Guofeng, LI Lei, WANG Ruixia, FANG Yanming. Imbibition displacement mechanism of fracturing fluid in shale oil reservoir [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(5): 756-763.
[4]	CAO Xiaopeng, LIU Haicheng, LI Zhongxin, CHEN Xianchao, JIANG Pengyu, FAN Hao. Optimization of huff-n-puff in shale oil horizontal wells based on EDFM [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(5): 734-740.
[5]	HE Faqi, LI Junlu, GAO Yilong, WU Jinwei, BAI Xingying, GAO Dun. Development characteristics and potential of fault-fracture reservoir in southwest margin of Ordos Basin [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(5): 667-677.
[6]	GAO Yuqiao, HE Xipeng, CHENG Xiong, TANG Xuan, HUA Caixia, ZAN Ling, ZHANG Peixian, CHEN Xuewu, PANG Yiwei. Discussion on high hydrocarbon generation efficiency of saline lacustrine source rocks with low TOC: A case study of the second member of Funing Formation, Qintong Sag, Subei Basin [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(5): 678-687.
[7]	SHU Qinglin,WEI Chaoping,YU Tiantian,JI Bingyu,ZHANG Zhongping,ZHENG Wangang. Development technology progress of heavy oil and establishment and application practice of new classification standard: A case study of development of heavy oil in Shengli Oilfield [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(4): 529-540.
[8]	CHEN Xiang, WANG Guan, LIU Pingli, DU Juan, WANG Ming, CHEN Weihua, LI Jinlong, LIU Jinming, LIU Fei. Experimental and simulation study on fracture conductivity of acid-fracturing in Dengying Formation of Sichuan Basin [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(4): 569-576.
[9]	LI Zhongchao, QI Guixue, LUO Bobo, XU Xun, CHEN Hua. Gas flooding adaptability of deep low permeability condensate gas reservoir [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(3): 324-332.
[10]	DUAN Hongliang,SHEN Tingshan,SUN Jing,HONG Yafei,LI Sichen,LU Xianrong,ZHANG Zhengyang. Experimental study of oil matrix and fracture flow capacity of shale oil in Subei Basin [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(3): 333-342.
[11]	KONG Xiangwei,XU Hongxing,SHI Xian,CHEN Hang. Experimental simulation of fracture initiation and morphology in tight sandstone gas reservoirs temporary plugging fracturing [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(3): 391-401.
[12]	ZHENG Yiqiong, ZHANG Tao, LIU Haiying, RUAN Conghui, ZOU Shuai. New strategies of beneficial development of in-situ combustion in nearly abandoned heavy oil reservoirs [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(3): 504-509.
[13]	LIU Xiao. Comparison of seam network morphology in coal reservoirs under different fracturing scales: A case of Yanchuannan CBM Gas Field [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(3): 510-518.
[14]	LI Ning,MIAO He,CAO Kaifang. Prediction of volcanic fractures based on prestack azimuthal anisotropy: A case study of LFS area in southern Songliao Basin [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(2): 197-206.
[15]	XU Guochen,DU Juan,ZHU Mingchen. Practice and understanding of water huff-n-puff in shale oil of Subei Basin [J]. Petroleum Reservoir Evaluation and Development, 2024, 14(2): 256-266.